4WD Actuator Harness or connector

Hello I have a 2003 Tundra (stepside model). My 4X4 switch has been flashing and found that the connector or wire harness has been chewed or cut by an animal or something. I've added new wire and crimped it. Worked for a little bit but eventually came out of crimp. I've run out of wire and I've been searching for the harness or connector as a whole. I cannot find the part number for it. It connects to the actuator as pictured below. Your help would be greatly appreciated.

 

Pics of offending female mating connector?

 

Man I wish I could remember who just had to go through this recently, with all the blinking lights crap ... he managed to find a harness p/n. If you wanted to hunt in the 'electrics' section of the EPC site, check the bullet points here: https://www.tundras.com/threads/howto-use-the-toyota-parts-system-to-find-order-parts.113808/

 

I found this in the wiring diagrams... Not sure if it is right but it sounds right.

Leads to this connector: https://www.bmotorsports.com/shop/p...Xmli3ZTU2vKO60kA1W6wKmKifkDrclqhoCyn8QAvD_BwE

 

Thanks so much guys. Ill check it out

 

Thanks again guys was able to find the harness. Ya'll are a blessing.

 

hey , where did you find the harness and connector?

 

On the truck, or the replacement parts? You’re not specifying which.

 

Sorry , the replacement part.

 

@BubbaW or @FiatRunner is this a part number you guys have on-hand by chance? I know there's a link in reply #3 of this thread that shows how to find the part number, but I guess @flowe wasn't able to use that for the harness in the EPC under Electrics > Wiring & Clamp (I know the connector is a separate thing, I think that p/n is in the EWDs or FSM). I found a wire "differential wire" in mine, which I think may be it, and the harness is still availbable, but I've got an '06 vs. his '01 so I'm sure it's not a matching part.

 

If you're asking about the Transfer Shift Actuator T 3 mentioned in above posts, your 01 would be same as the 03 part # wise....90980−11858, that @APalmTree linked to above.

Home » Shop » Connectors / Harnesses » Yazaki » Toyota & Mazda 6 Way TPS Connector Kit, Black - 90980-11858

As for the harness, that's a multi-connector Engine Wire harness unfortunately.

 

What Bubba said. Part 90980-11858, found on page 232 of the EWD, I've actually printed this page out because I've used it so many times.


I also added the wiring diagram .pdf for a 2002, which should be the same as the 2003 for 4WD related stuff.